1238 Simpson WayEscondidoCA 92029, USA

OUR STAFF


Our staff are California State Fire Mechanic Certified in many various areas and have continued education both with the CFMA and apparatus manufacturers to stay up with the latest in technology.  Our goal is to ensure that the job is done 100% correct the first time. Our staff run all systems and run the vehicle in "real world" scenarios.  We go above an beyond the minimum requirements that is required by the D.O.T and NFPA standards. We know that a well-maintained vehicle is a reliable vehicle and nothing is more important when you are going on that emergency call than knowing that your are not going to have any issues getting there.


We work very close with fire departments to make sure that we are always available to make sure that your vehicles are in top working condition 24/7/365.

BIT Pros, Inc. ©

(760) 839-2641

PREVENTIVE MAINTENANCE


ENGINE

Oil Level, Oil Filters, Cooling System Fluid Levels, Coolant Filter, Coolant System Hose's, Coolant Tested, Fuel Filter, Air Filter, Belt, Motor Mounts, Exhaust System, Air Compressor Filter, Air System and Drains, Emergency Shutdown and Shutter Operation.


CHASSIS

Lube Chassis, Clutch Linkage, Check Drive Line, Differential Fluid Level, Gaskets and Seals, Mounting Bolts/Body, Axle Studs and Nuts, Springs and U Bolts, Shackle Pins, Shock Absorbers, Tires, Wheels and Lug Nuts, Fuel Tank, Power Steering Fluid Level/Filter/Pump, Hose and Filters, Drag Link and Asst. Cylinder, Tie Rod Ends, Kings Pins, Steering Gear Box Assembly and Gear Mounting Bolts.


TRANSMISSION

Fluid Level, Shift Linkage (Manual), Gaskets and Seals, Lock-up System, Filter, Cooler, PTO.


BRAKES

Fluid Level, Low Air Alarm, Governor, Leakage, Tank Drains, Air Dryer System, Alcohol Evap. System, Moisture Ejectors, Parking, Brake Linings and Adjust, Brake Chambers, Tubing/Lines/Fittings and Drums/Rotators.

ELECTRICAL SYSTEM

Starting System, Onboard Air Compressor, Charging System, Battery Condition, Battery Load Test, Alternator AMPS Output, Warning Lights, Sirens, Ground/Step Lights, Pump Panel Lights, Compartment Lights,DOT Lights, Gaskets and Seals and Axle Bearings.


FIRE PUMPS

Change Over Valve, Relief Valve, Pressure Governor, Controls/Linkage, Strainers, Priming System, Gauges, Drains and Bleeders, Pump Packing, Valves, Anodes and Heat Exchanger Valve.

PUMP TRANSMISSION

Oil Level, Noise, Linkage and Control, Mounting Bolts and Gaskets/Seals.


BOOSTER TANK

Dump Chutes, Leaks/Overflow Piping and Tank Seal.


FOAM TANK

Foam System and Soam System Piping.


PORTABLE PUMP

Remote Start, Battery, Oil/Oil Filter, Fuel Filter, Air Filter, Exhaust System, Controls/Linkage, Mounting Bolts, Valves, Packings, “T” Case, Oil and Noise.


CAB

Wipers/Wash, Headlights, DOT Lights, Instruments and Controls, Glass, Seats and Seat Belts, Door Latches and Locks, Heater Defroster, HVAC System, Cab Tilt/Locks/Pivot, Cab Tilt Cylinders, Spot Lights and Interior Lights.


GENERATOR/INVERTER

Remote Start, Oil/Hydraulic Filter, Fuel Filters, Air Filters, Exhaust System, Quartz Lights, receptacles and PTO/Pump.